CALGARY — The National Energy Board says poor oversight and communication were to blame for an Enbridge natural gas pipeline fire west of Toronto more than three years ago.

In September 2009, a contractor was working on the line in Mississauga, Ont., and damaged part of it, causing gas to escape and ignite. A flame shot up 50 metres into the air.

"Examination of the evidence, documents gathered, and interviews conducted indicate that the incident was preceded by a number of contributing conditions and unsafe acts,'' the NEB said in a report released this week.

No one was hurt in the fire and the environmental impact was limited, but a building, vehicles and construction equipment were damaged. Nearby businesses, including a strip mall and daycare, were evacuated as a precaution.

A report by the federal energy watchdog released this week says the incident was ``preventable.''

"Though no people were injured and the incident resulted in minimal impacts to public safety, the environment or the economy, the potential impact of an event of this magnitude cannot be ignored,'' it said.

The NEB says Enbridge's gas distribution unit did not have a copy of its safety manual on site and didn't adequately communicate hazards to contracted workers or make sure they were following proper procedures.

The fire took place as Enbridge's contractor, Robert B. Somerville Co. Ltd., was installing new pipe at Enbridge's Lisgar Gate Station.

In order to facilitate the welders' work, the pipe they were working on was rotated. An Enbridge representative oversaw the first movement, but had left the site to buy supplies for a second rotation.

During the second turn, a piece of equipment capping off end of the existing pipeline was knocked free, leading gas to be released, the NEB said.

"Interviews with (Enbridge Gas Distribution) staff, management and the contracted workers provided the evidence that there was inadequate communication between EGD field staff and the contractor,'' the report said.

Both Enbridge (TSX:ENB) the contractor have pleaded guilty to violations under the Ontario Occupational Health and Safety Act and the Ontario Court of Justice has sentenced each to a $50,000 fine.

The NEB report comes as Enbridge tries to win regulatory approval to build a controversial $6-billion pipeline connecting oilsands crude to the West Coast for export. Opponents say a spill from the line itself or from tankers along the coast could cause dire environmental harm.

Also on HuffPost:

Loading Slideshow...
  • 10. Oil And Gas Accounts For 4.8 Per Cent Of GDP

    The oil and gas industries accounted for around $65 billion of economic activity in Canada annually in recent years, or slightly less than 5 per cent of GDP. Source: <a href="http://www.ceri.ca/docs/2010-10-05CERIOilandGasReport.pdf" target="_hplink">Canada Energy Research Institute</a>

  • 9. Oil Exports Have Grown Tenfold Since 1980

    Canada exported some 12,000 cubic metres of oil per day in 1980. By 2010, that number had grown to 112,000 cubic metres daily. Source: <a href="http://membernet.capp.ca/SHB/Sheet.asp?SectionID=9&SheetID=224" target="_hplink">Canadian Association of Petroleum Producers</a>

  • 8. Refining Didn't Grow At All As Exports Boomed

    Canada refined 300,000 cubic metres daily in 1980; in 2010, that number was slightly down, to 291,000, even though exports of oil had grown tenfold in that time. Source: <a href="http://membernet.capp.ca/SHB/Sheet.asp?SectionID=7&SheetID=104" target="_hplink">Canadian Association of Petroleum Producers</a>

  • 7. 97 Per Cent Of Oil Exports Go To The U.S.

    Despite talk by the federal government that it wants to open Asian markets to Canadian oil, the vast majority of exports still go to the United States -- 97 per cent as of 2009. Source: <a href="http://www.nrcan.gc.ca/statistics-facts/energy/895" target="_hplink">Natural Resources Canada</a>

  • 6. Canada Has World's 2nd-Largest Proven Oil Reserves

    Canada's proven reserves of 175 billion barrels of oil -- the vast majority of it trapped in the oil sands -- is the second-largest oil stash in the world, after Saudi Arabia's 267 billion. Source: <a href="http://www.ogj.com/index.html" target="_hplink">Oil & Gas Journal</a>

  • 5. Two-Thirds Of Oil Sands Bitumen Goes To U.S.

    One-third of Canada's oil sands bitumen stays in the country, and is refined into gasoline, heating oil and diesel. Source: <a href="http://www.nrcan.gc.ca/statistics-facts/energy/895" target="_hplink">Natural Resources Canada</a>

  • 4. Alberta Is Two-Thirds Of The Industry

    Despite its reputation as the undisputed centre of Canada's oil industry, Alberta accounts for only two-thirds of energy production. British Columbia and Saskatchewan are the second and third-largest producers. Source: <a href="http://www.nrcan.gc.ca/statistics-facts/energy/895" target="_hplink">Natural Resources Canada</a>

  • 3. Alberta Will Reap $1.2 Trillion From Oil Sands

    Alberta' government <a href="http://www.huffingtonpost.ca/2012/03/27/alberta-oil-sands-royalties-ceri_n_1382640.html" target="_hplink">will reap $1.2 trillion in royalties from the oil sands over the next 35 years</a>, according to the Canadian Energy Research Institute.

  • 2. Canadian Oil Consumption Has Stayed Flat

    Thanks to improvements in energy efficiency, and a weakening of the country's manufacturing base, oil consumption in Canada has had virtually no net change in 30 years. Consumption went from 287,000 cubic metres daily in 1980 to 260,000 cubic metres daily in 2010. Source: Source: <a href="http://membernet.capp.ca/SHB/Sheet.asp?SectionID=6&SheetID=99" target="_hplink">Canadian Association of Petroleum Producers</a>

  • 1. 250,000 Jobs.. Plus Many More?

    The National Energy Board says oil and gas employs 257,000 people in Canada, not including gas station employees. And the Canadian Association of Petroleum Producers says the oil sands alone <a href="http://www.capp.ca/aboutUs/mediaCentre/NewsReleases/Pages/OilsandsaCanadianjobcreator.aspx" target="_hplink">will grow from 75,000 jobs to 905,000 jobs by 2035</a> -- assuming, of course, the price of oil holds up.